Computationally Investigate Low Velocity Hydrokinetic Turbines with Variant Systems

Document Type : Regular Article

Authors

1 Sarvajanik College of Engineering & Technology, Surat, Gujarat, 395001, India

2 SardarVallabhbhai National Institute of Technology, Surat, Gujarat, 395007, India

3 Gujarat Technological University, Ahmedabad, Gujarat, 382424, India

Abstract

A high velocity is rarely accessible in water streams such as rivers, canals, and outlets of sewage and common effluent treatment plants. However, an average velocity of 0.5 - 1.0 m/s is reported to be available in many water streams most of the time. Hydrokinetic (HK) turbines can extract power from the flowing water in these streams. Considering the small quantum of power generated, the economic factor is more significant than efficiency. A Savonius-type HK turbine can generate energy from low-velocity magnitudes of around 0.5 m/s, although it remains a low-speed and low-efficiency turbine. In this study, an attempt has been made to computationally investigate the performance of the Savonius turbine in a water stream channel. It is observed that the performance of the Savonius turbine is not significant, and the generated power cannot be utilized constructively for different applications. Therefore, it is necessary to develop and investigate variant constructive systems to enhance turbine performance. This manuscript focuses on exploring these variant systems and understanding their performance characteristics. Four variant systems have been selected: (i) System-1: Solely Savonius turbine, (ii) System-2: Savonius turbine with a flume, (iii) System-3: Deflector section used before the flume, and (iv) System-4: Deflector section used before the turbine. The investigation was carried out for these four variant systems using the Fluent commercial code. The results indicate that the Coefficient of performance (Cp) is low for System-1, solely Savonius turbine, with a value of 0.052. For the other variants, Cp values were found to be 0.357, 1.385, and 0.579 for the turbine with a flume, deflector before the flume, and deflector before the turbine respectively at the Tip Speed Ratio (TSR) is 1. Moreover, the study also extends to optimizing Cp under different TSR for the different variant systems. The intention is to use this study to install an HK turbine with an optimum constructive structure for maximizing and stabilizing the power that can be used for an isolated application.

Keywords

Main Subjects

References

Alizadeh, H., Jahangir, M. H., & Ghasempour, R. (2020). CFD-based improvement of Savonius type hydrokinetic turbine using optimized barrier at the low- speed flows. Ocean Engineering, 202, 1-8. https://doi.org/10.1016/j.oceaneng.2020.107178
Asim, T., Mishra, R., Ubbi, K., & Zala, K. (2013). Computational fluid dynamics based optimal design of vertical axis marine current turbines. Procedia CIRP, 11, 323–327. https://doi.org/10.1016/j.procir.2013.07.023
Castelli, M. R., Englaro, A., & Benini, E. (2011). The darrieus wind turbine: proposal for a new performance prediction model based on CFD. Energy, 36(8), 4919–4934. https://doi.org/10.1016/j.energy.2011.05.036
Chen, Y., Guo, P., Zhang, D., Chai, K., Zhao, C., & Li, J. (2022). Power improvement of a cluster of three Savonius wind turbines using the variable-speed control method. Renewable Energy, 193, 832-842. https://doi.org/10.1016/j.renene.2022.05.062.
Driss, Z., Jemni, M. A., Chelly, A., & Abid, M. S. (2013). Computational study of a vertical axis water turbine placed in a hydrodynamic test bench. International Journal of Mechanics and Applications, 3(4), 98–104. https://doi.org/10.5923/j.mechanics.20130304.06
Elbatran, A. H., Ahmed, Y. M., & Shehata, A. S. (2017). Performance study ofducted nozzle Savonius water turbine, comparison with conventional Savonius turbine. Energy, 134, 566-584. https://doi.org/10.1016/j.energy.2017.06.041
Golecha, K., Eldho, T. I., & Prabhu, S. V. (2011). Influence of the deflector plate on the performance of modified Savonius water turbine. Applied Energy, 88(9), 3207–3217. https://doi.org/10.1016/j.apenergy.2011.03.025
Golecha, K., Eldho, T. I., & Prabhu, S. V. (2012). Performance study of modified Savonius water turbine with two deflector plates. International Journal of Rotating Machinery, 1-12. https://doi.org/10.1155/2012/679247
IEC 60041/IS 41. 1991. Field acceptance tests to determine the hydraulic performance of hydraulic turbines storage pumps and pump turbines. Bureau of Indian standards, New Delhi. https://archive.org/details/gov.in.is.iec.41.1991
Johnson, J. B., & Pride, D. J. (2010). River, tidal, and ocean current hydrokinetic energy technologies: status and future opportunities in Alaska. Alaska Centre for Energy and Power. Chrome-extension://efaidnbmnnnibpcajpcglclefindmkaj/https://tethys.pnnl.gov/sites/default/files/publications/Johnson_Pride_2010.pdf
Kerikous, E., & Thévenin, D. (2019). Optimal shape and position of a thick deflector plate in front of a hydraulic Savonius turbine. Energy, 189, 116-157. https://doi.org/10.1016/j.energy.2019.116157
Kolekar, N., & Banerjee, A. (2015). Performance characterization and placement of a marine hydrokinetic turbine in a tidal channel under boundary proximity and blockage effects. Applied Energy, 148, 121-133.
Kumar, A., & Saini, R. P. (2017a). Performance analysis of a single stage modified Savonius hydrokinetic turbine having twisted blades. Renewable Energy, 113, 461-478. https://doi.org/10.1016/j.renene.2017.06.020
Kumar, A., & Saini, R. P. (2017b). Performance analysis of a Savonius hydrokinetic turbinehaving twisted blades. Renewable Energy, 108, 502-522. https://doi.org/10.1016/j.renene.2017.03.006
Kusakana, K., & Vermaak, H J. (2013). Hydrokinetic power generation for rural electricity supply: case of South Africa. Renewable Energy, 55, 467–73. https://doi.org/10.1016/j.renene.2012.12.051
Loureiro, J. B. R., & Silva Freire, A. P. (2005). Experimental investigation of turbulent boundary layers over steep two-dimensional elevations. Journal of Brazilian Society of Mechanical Sciences and Engineering, 27(4), 329-344. https://doi.org/10.1590/S1678-58782005000400001
Mohamed, M. H. (2012). Performance investigation of H-rotor Darrieus turbine with new airfoil shapes. Energy, 47(1), 522–530. https://doi.org/10.1016/j.energy.2012.08.044
Mohamed, M. H. (2013). Impacts of solidity and hybrid system in small wind turbines performance. Energy, 57(1), 495–504. https://doi.org/10.1016/j.energy.2013.06.004
Mohamed, M. H., Ali, A. M., & Hafiz, A. A. (2015). CFD analysis for H-rotor Darrieus turbine as a low speed wind energy converter. Engineering Science and Technology, an International Journal, 18(1), 1–13. https://doi.org/10.1016/j.jestch.2014.08.002
Mohamed, M. H., Janiga, G., Pap, E., & Thevenin, D. (2010). Optimization of savonius turbines using an obstacle shielding the returning blade. Renewable Energy, 35(11), 2618–2626. https://doi.org/10.1016/j.renene.2010.04.007
Mohamed, M. H., Janiga, G., Pap, E., & Thevenin, D. (2011a). Multi-objective optimization of the airfoil shape of Wells turbine used for wave energy conversion. Energy, 36(1), 438-446. https://doi.org/10.1016/j.energy.2010.10.021
Mohamed, M. H., Janiga, G., Pap, E., & Thevenin, D. (2011b). Optimal blade shape of a modified Savonius turbine using an obstacle shielding the returning blade. Energy Conversion and Management, 52(1), 236–42. https://doi.org/10.1016/j.enconman.2010.06.070
Mosbahi, M., Ayadi, A., Chouaibi, Y., Driss, Z., & Tucciarelli, T. (2019a). Performance study of a helical Savonius hydrokinetic turbine with a new deflector system design. Energy Conversion and Management, 194, 55–74. https://doi.org/10.1016/j.enconman.2019.04.080
Mosbahi, M., Ayadi, A., Mabrouki, I., Driss, Z., Tucciarelli, T., & Abid, M. S. (2019b). Effect of the converging pipe on the performance of a lucid spherical rotor. Arabian Journal for Science and Engineering, 44(2), 1583–600. https://doi.org/10.1007/s13369-018-3625-0
Nag, A. K., & Sarkar, S. (2021). Techno-economic analysis of a micro-hydropower plant consists of hydrokinetic turbines arranged in different array formations for rural power supply. Renewable Energy, 179, 475-487. https://doi.org/10.1016/j.renene.2021.07.067.
Nakajima, M., Iio, S., & Ikeda, T. (2008). Performance of Savonius rotor for environmentally friendly hydraulic turbine. Journal of Fluid Science and Technology, 3(3), 420–429. https://doi.org/10.1299/jfst.3.420
Patel, V., Bhat, G., Eldho, T. I., & Prabhu, S. V. (2017). Influence of overlap ratio and aspect ratio on the performance of Savonius hydrokinetic turbine. International Journal of Energy Research, 41, 829–844. https://doi.org/10.1002/er.3670
Patel, V., Eldho, T. I., & Prabhu, S. V. (2018). Theoretical study on the prediction of the hydrodynamic performance of a Savonius turbine based on stagnation pressure and impulse momentum principle. Energy Conversion and Management, 168, 545-563. https://doi.org/10.1016/j.enconman.2018.04.065
Patel, V., Eldho, T. I., & Prabhu, S. V. (2019). Velocity and performance correction methodology for hydrokinetic turbines experimented with different geometry of the channel. Renewable Energy, 131, 1300-1317. https://doi.org/10.1016/j.renene.2018.08.027
Ponta, F., & Dutt, G. S. (2000). An improved vertical axis water current turbine incorporating a channelling device. Renewable Energy, 20, 223–241. https://doi.org/10.1016/S0960-1481(99)00065-8
Riglin, J., Schleicher, W. C., Liu, I. H., & Oztekin, A. (2015). Characterization of a micro-hydrokinetic turbine in close proximity to the free surface. Ocean Engineering, 110, 270–280. https://doi.org/10.1016/j.oceaneng.2015.10.026
Roy, S., & Saha, U. K. (2013). Computational study to assess the influence of overlap ratio on static torque characteristics of a vertical axis wind turbine. Procedia Engineering, 51, 694–702. https://doi.org/10.1016/j.proeng.2013.01.099
Saini, G., & Saini, R. P. (2018). A Numerical analysis to study the effect of radius ratio and attachment angle on hybrid hydrokinetic turbine performance. Energy for Sustainable Development, 47, 94–106. https://doi.org/10.1016/j.esd.2018.09.005
Sarma, N. K., Biswas, A., & Misra, R. D. (2014). Experimental and computational evaluation of Savonius hydrokinetic turbine for low velocity condition with comparison to Savonius wind turbine at the same input power. Energy Conversion and Management, 83, 88–98. https://doi.org/10.1016/j.enconman.2014.03.070
Shashikumar, C. M., Hindasageri, V., & Madav, V. (2021a, February). CFD investigation of unsteady three-dimensional savonius hydrokinetic turbine in irrigation channel with varying positions for hydro power application. AIP Conference Proceedings. AIP Publishing. https://doi.org/10.1063/5.0036472.
Shashikumar, C. M., Vijaykumar, H., & Vasudeva, M. (2021b). Numerical investigation of conventional and tapered Savonius hydrokinetic turbines for low-velocity hydropower application in an irrigation channel. Sustainable Energy Technologies and Assessment Journal, 43; 100871 (Online). https://doi.org/10.1016/j.seta.2020.100871.
Singh, S. V., & Kumar, P. (2022). Study of flow characteristics of a savonius turbine inside nozzle diffuser duct. Journal of Engineering Research. https://doi.org/10.36909/jer.15977.
Talukdar, P. K., Sardar, A., Kulkarni, V., & Saha, U. K. (2018). Parametric analysis of model Savonius hydrokinetic turbines through experimental and computational investigations. Energy Conversion and Management, 158, 36-49. https://doi.org/10.1016/j.enconman.2017.12.011
Thakur, N., Biswas, A., Kumar, Y., & Basumatary, M.  (2019). CFD analysis of performance improvement of the Savonius water turbine by using an impinging jet duct design. Chinese Journal of Chemical Engineering, 27(4), 794-801. https://doi.org/10.1016/j.cjche.2018.11.014
Wahyudi, B., Soeparman, S., Wahyudi, S., & Denny, W. (2013). A simulation study of Flow and Pressure distribution patterns in and around of Tandem Blade Rotor of Savonius (TBS) Hydrokinetic turbine model. Journal of Clean Energy Technologies, 1, 286–291. https://doi.org/10.7763/JOCET.2013.V1.65
Zhang, B., Song, B., Mao, Z., & Tian, W. (2017). A novel wake energy reuse method to optimize the layout for Savonius-type vertical axis wind turbines. Energy, 121, 341–355. https://doi.org/10.1016/j.energy.2017.01.004
Zhao, Z., Zheng, Y., Xu, X., Liu, W., & Hu, G. (2009). Research on the improvement of the performance of Savonius rotor based on numerical study. International Conference on Sustainable Power Generation and Supply, 1–6. https://doi.org/10.1109/SUPERGEN.2009.5348197
Zhou, T., & Rempfer, D. (2013). Numerical study of detailed flow field and performance of Savonius wind turbines. Renewable Energy, 51, 373–381. https://doi.org/10.1016/j.renene.2012.09.046

Files

History

  • Received: 04 May 2024
  • Revised: 24 September 2024
  • Accepted: 26 September 2024
  • Available online: 01 January 2025

Share

How to cite

Statistics