Influence of Flow-induced Vibration of a D-VAWT With and Without Leading-edge Rod at Various Pitch Angles

Document Type : Regular Article

Authors

Turbulence & Flow Control Laboratory, School of Mechanical Engineering, SASTRA Deemed to be University, Thanjavur, Tamil Nadu-613401, India

10.47176/jafm.18.7.3173

Abstract

Under specific incoming wind speeds, Darrieus- Vertical Axis Wind Turbines (D-VAWT) have been found to display significant amplitude vibrations. Previous studies mainly examined the D-VAWT's aerodynamics, ignoring flow-induced vibration (FIV). A full-scale measurement of the VAWT mast support structure is used to study the impact of the incoming wind speed (V) and pitch angle (α). The D-VAWT's rotor rotates when the incoming wind encounters its blades, causing vibrations to be transmitted to the turbine's shaft and other supporting elements. As a result, tip speed and pitch angle, which aid in the turbine's rotation, also play a significant role in producing the FIV. Based on the rotation law, the D-VAWT's rotational rate and the enforced Pitch are proportionate to the cylinder displacement. In contrast to the prior report, the vibrations are caused by vortex-induced vibration (V.I.V.) and galloping, which depend on the turbine's pitch angle and tip speed. V.I.V. predominates at high-pitch angles, while galloping is more common at high blade tip speeds and low-pitch angles. Lastly, a leading-edge rod (L.R.) with a 4 mm diameter is fastened to the turbine's blades to suppress V.I.V., which yields a reasonable outcome. Henceforth, this was the first experimental investigation to comprehend the galloping instability and V.I.V. in D-VAWT at various pitch angles and tip speeds.

Keywords

Main Subjects


Abdelkefi, A., Hajj, M. R., & Nayfeh, A. H. (2012). Power harvesting from transverse galloping of square cylinder. Nonlinear Dynamics, 70(2), 1355–1363. https://doi.org/10.1007/s11071-012-0538-4
Al-Mdallal, Q. M. (2004). Analysis and computation of the cross-flow past an oscillatiang cylinder with two degrees of freedom [Doctoral Dissertation, Memorial University of Newfoundland].
Bachant, P., & Wosnik, M. (2016). Effects of Reynolds number on the energy conversion and near-wake dynamics of a high solidity vertical-axis cross-flow turbine. Energies, 9(2), 73. https://doi.org/10.3390/en9020073
Bel Mabrouk, I., ELHami, A., Walha, L., Zghal, B., & Haddar, M. (2017). Dynamic vibrations in wind energy systems: Application to vertical axis wind turbine. Mechanical Systems and Signal Processing, 85, 396–414. https://doi.org/10.1016/j.ymssp.2016.08.034
Blackburn, H. M., Elston, J. R., & Sheridan, J. (1999). Bluff-body propulsion produced by combined rotary and translational oscillation. Physics of Fluids, 11(1), 4–6. https://doi.org/10.1063/1.869912
Castellani, F., Astolfi, D., Becchetti, M., & Berno, F. (2018). Experimental and numerical analysis of the dynamical behavior of a small horizontal-axis wind turbine under unsteady conditions: Part I. Machines, 6(4). https://doi.org/10.3390/machines6040052
Dunne, R., & McKeon, B. J. (2015). Dynamic stall on a pitching and surging airfoil. Experiments in Fluids, 56(8), 157. https://doi.org/10.1007/s00348-015-2028-1
Elangovan, K., & Pillai, S. N. (2025). Effect of pitch angle on structural and aerodynamic characteristics of vertical-axis wind turbines (VAWTs) using leading-edge protuberance blades. Energies, 18(2), 286. https://doi.org/10.3390/en18020286
Fatahian, E., Ismail, F., Ishak, M. H. H., & Chang, W. S. (2024). Novel passive flow control method using leading-edge prism-shaped cylinder: Performance enhancement of vertical-axis wind turbines. Physics of Fluids, 36(11). https://doi.org/10.1063/5.0233464
Govardhan, R. N., & Williamson, C. H. K. (2006). Defining the ‘modified Griffin plot’ in vortex-induced vibration: revealing the effect of Reynolds number using controlled damping. Journal of Fluid Mechanics, 561, 147–180. https://doi.org/10.1017/S0022112006000310
Hamdi, H., Mrad, C., Hamdi, A., & Nasri, R. (2014). Dynamic response of a horizontal axis wind turbine blade under aerodynamic, gravity and gyroscopic effects. Applied Acoustics, 86, 154–164. https://doi.org/10.1016/j.apacoust.2014.04.017
Kaczinski, M. R., Dexter, R. J., & Van Dien, J. P. (1998). Fatigue-resistant design of cantilevered signal, sign and light supports. Nchrp: Vol. NCHRP Repo (p. 176).
Karthik Vel, E., & Nadaraja Pillai, S. (2024). Vibration control of the straight bladed vertical axis wind turbine structure using the leading-edge protuberanced blades. Engineering Structures, 319, 118806. https://doi.org/https://doi.org/10.1016/j.engstruct.2024.118806
Lu, L., Qin, J. M., Teng, B., & Li, Y. C. (2011). Numerical investigations of lift suppression by feedback rotary oscillation of circular cylinder at low Reynolds number. Physics of Fluids, 23. https://doi.org/10.1063/1.3560379
Maheswaran, C. B., Gopal, R., Chandrasekar, V. K., & Pillai, S. N. (2023). Chaotic vibration characteristics of Vertical Axis Wind Turbine (VAWT) shaft system. Wind and Structures, An International Journal, 36(3), 215–220. https://doi.org/10.12989/was.2023.36.3.215
McLaren, K., Tullis, S., & Ziada, S. (2012). Measurement of high solidity vertical axis wind turbine aerodynamic loads under high vibration response conditions. Journal of Fluids and Structures, 32, 12–26. https://doi.org/https://doi.org/10.1016/j.jfluidstructs.2012.01.001
Miller, M. A., Duvvuri, S., Brownstein, I., Lee, M., Dabiri, J. O., & Hultmark, M. (2018). Vertical-axis wind turbine experiments at full dynamic similarity. Journal of Fluid Mechanics, 844, 707–720. https://doi.org/10.1017/jfm.2018.197
Mohamed, M. H. (2012). Performance investigation of H-rotor Darrieus turbine with new airfoil shapes. Energy, 47(1), 522–530. https://doi.org/10.1016/j.energy.2012.08.044
Davandeh, N., & Maghrebi, M. J. (2023). Leading Edge Radius Effects on VAWT Performance. Journal of Applied Fluid Mechanics, 16(9). https://doi.org/10.47176/jafm.16.09.1626
Nazarinia, M., Lo Jacono, D., Thompson, M. C., & Sheridan, J. (2009a). Flow behind a cylinder forced by a combination of oscillatory translational and rotational motions. Physics of Fluids, 21(5), 51701. https://doi.org/10.1063/1.3139184
Nazarinia, M., Lo Jacono, D., Thompson, M. C., & Sheridan, J. (2009b). The three-dimensional wake of a cylinder undergoing a combination of translational and rotational oscillation in a quiescent fluid. Physics of Fluids, 21(6), 64101. https://doi.org/10.1063/1.3147935
Nguyen, M. T., Balduzzi, F., & Goude, A. (2021). Effect of pitch angle on power and hydrodynamics of a vertical axis turbine. Ocean Engineering, 238, 109335. https://doi.org/https://doi.org/10.1016/j.oceaneng.2021.109335
Peng, Y. X., Xu, Y. L., Zhan, S., & Shum, K. M. (2019). High-solidity straight-bladed vertical axis wind turbine: Aerodynamic force measurements. Journal of Wind Engineering and Industrial Aerodynamics, 184, 34–48. https://doi.org/10.1016/j.jweia.2018.11.005
Piersol, A. G., & Paez, T. L. (Eds.). (2010). Harris’ Shock and Vibration Handbook (6th Editio). McGraw-Hill Education.
Ross, H., & Polagye, B. (2022). Effects of dimensionless parameters on the performance of a cross-flow current turbine. Journal of Fluids and Structures, 114, 103726. https://doi.org/https://doi.org/10.1016/j.jfluidstructs.2022.103726
Simão Ferreira, C. J., Bijl, H., Van Bussel, G., & Van Kuik, G. (2007). Simulating dynamic stall in a 2D VAWT: Modeling strategy, verification and validation with particle image velocimetry data. Journal of Physics: Conference Series, 75(1). https://doi.org/10.1088/1742-6596/75/1/012023
Singh, S. P., & Mittal, S. (2005). Flow past a cylinder: Shear layer instability and drag crisis. International Journal for Numerical Methods in Fluids, 47(1), 75–98. https://doi.org/10.1002/fld.807
Vicente-Ludlam, D., Barrero-Gil, A., & Velazquez, A. (2017). Flow-Induced Vibration of a rotating circular cylinder using position and velocity feedback. Journal of Fluids and Structures, 72, 127–151. https://doi.org/https://doi.org/10.1016/j.jfluidstructs.2017.05.001
Wei, S., Zhao, J. S., Han, Q., & Chu, F. (2015). Dynamic response analysis on torsional vibrations of wind turbine geared transmission system with uncertainty. Renewable Energy, 78. https://doi.org/10.1016/j.renene.2014.12.062
Zhong, J., Li, J., Guo, P., & Wang, Y. (2019). Dynamic stall control on a vertical axis wind turbine aerofoil using leading-edge rod. Energy, 174, 246–260. https://doi.org/10.1016/j.energy.2019.02.176
Zuo, D., & Letchford, C. (2010). Wind-induced vibration of a traffic-signal-support structure with cantilevered tapered circular mast arm. Engineering Structures, 32, 3171–3179. https://doi.org/10.1016/j.engstruct.2010.06.005